Well, finally its time to assemble my first rounds!
The Equipment and Supplies
 The Class Lee Loader -- a simple set of tools that works very well.
|  |
First, I gathered up all my equipment.
The most important part is the loading equipment -- the Classic Lee Loader set in .38 Special. Available at www.leeprecision.com. This kit is just about everything you need to load your own ammo. The other necessity is a rubber mallet. I bought a 12 oz. soft hammer/mallet at Home Depot for about $12.
As for hardware, you might also need a scale to weigh (or verify the weight) of your charges (not absolutely necessary -- more on that later) and a caliper to measure the finished cartridge's overall length.
Finally, you need your consumable materials. I visited my local reloading supply house and bought Winchester 231 powder, CCI small pistol primers, and some empty .38 Special brass. Obviously you can save a lot of money by reloading your own fired brass, but I didn't have any saved up. I will be saving the brass in the future. You should also purchase a tube of case lubricant. I bought the Lee Resizing Lubricant and it worked very well.
 All the tools and supplies used in my first reloading session.
|  |
The only other tools I used was a piece of cardboard to protect my workbench, safety glasses, a pen and a laptop computer (with internet access) to view the reloading data tables on Winchester's website (www.wwpowder.com).
The Loading Process
I am not going to describe the loading process in excruciating detail. There are better websites for that. One in particular is: http://www.beartoothbullets.com/tech_notes/archive_tech_notes.htm/51 If you are looking for expertise in reloading from me, you obviously haven't read the introduction to this blog!
I will tell you that the loading process is relatively easy if you follow all the steps as outlined in the Lee manual that accompanies the kit. The manual is nicely illustrated with photos and the tools are all marked in such a fashion that it is easy to understand the use and orientation of the tool for each step.
In essence, the process is as follows. First, you de-prime the case (if necessary) by taping out the spent primer with an appropriate tool and your mallet. Then you drive the case into the sizing die. This takes some force and the case needs to be lightly lubricated first.
With the case still lodged in the sizing die, you place a primer on the priming chamber tool and gently pound the sized case out of the die, seating the primer in the process. Then you completely remove the now-primed case from the die.
Next, you gently tap in the flaring tool to open up the case mouth a bit for the bullet. You then add an appropriate powder measure. This was the first hiccup in the process. The Lee Loader comes with a powder dipper to measure powder by volume. However, it is calibrated to certain listed powders, but not Winchester 231. As such, I used a scale to measure the power charges. This was slower, but I wasn't sure what else to do at this point. The scale shown is a very nice Dillon Precision (www.bluepress.com) D-Terminator scale. This scale may be more than you need if you budget is tight, but I had one available and it was nice to have.
You then drop a bullet into the die and tap it into the case with the bullet seater. This seemed to be the most subjective part to me. The bullet seater is adjustable for depth, but you have to kind of figure it out by trial and error. My first loaded round wound up with the bullet a little too deep. I didn't have a bullet puller, so I couldn't fix it. The caliper is used to measure cartridge overall length, which is another measurement provided in the loading tables. Loads that are too short can greatly increase the pressure generated, which can be dangerous.
The last step is to turn the sizing die around and use the other end to crimp the bullet in the case with a few light taps. And then -- you have a finished round! Pretty cool!
 My first properly loaded round in .38 Special!
|  |
A few lessons learned so far:
- Assemble all the tools and materials first -- don't get started until you are ready.
- Read the instructions through several times before you start. Read some reliable instructions on the web too, if you can find them. If you have a friend who knows the process, that is even better!
- Don't forget the case lube. Its necessary to make the whole sizing process work well.
- Be careful not to seat the bullet too deep. Work it in slowly and adjust your bullet seating tool as you go. Remember to check the overall length against published minimums.
- Your kitchen table is not an ideal place to load. Lots of hammering and such. You are better off in the garage if you have one.
All in all, the process was pretty simple. Its also pretty slow. If I got on a roll, I suppose I could load a box of 50 in about an hour? Maybe more&
A final note on safety. At first, I was a little nervous about pounding on the case when seating the primer. But, the set works in a very clever manner that seems to be exceptionally safe. Without a doubt though, were safety goggles when you load.
I loaded a few rounds tonight, and I will load a few more when time permits. If nothing else, I think this has given me an appreciation for how simple the process can be, and gives me some insight on how a loading press is going to work.
So far, so good!